Today we would like to give information regarding to the Ford or Mazda B series broken door latches.
The very common reason for this problem is unfortunately Ford made a poor engineering decision with the cable ends in the latch system and made them out of plastic. During the time metal hinge pivots against the plastic end to open the latch and after a while plastic end becomes brittle and breaks so when you buy a Ford or Mazda B series trucks and vans after a few years you will face that your rear doors won’t open even though you are pulling on the door handle.
Here is a newest best permanent solution from Tulga Fifth Wheel to repair you doors with an inexpensive solution made by an aircraft grade Aluminum 6061 T6 material that will lasts forever!
I can hear you guys paid hundreds of dollars to have your doors repaired by the dealer for buying entire cable assembly and installation.
Solution is just for $9.99 !!!
There are lots of people selling cable repair kit that you have to pay attention not to purchase a useless kits.
Tulga Ford door cable repair kit includes 3 standard cable ferrules and 1 cam-style cable ferrule.
The cam-style cable ferrule is a new design and makes it much easier to install the ferrule without having to bend the housing bracket into place. You can really see the importance of it.
Here we removed upper latch from the vehicle just to show you how works the cam piece and you notice that the cam piece lower part is specifically designed into the part and it is meant to fit into the upper latch that you are going to put a very little force behind it to get into then give it about 180° to turn and now it is locked in the place.
If you purchase the kits without the cam piece you need to spend a lot of hours rework and you might have to take a trip to a Ford dealership if you damage your upper large that will cost hundreds of dollars again! Lots of people used 4 pieces standard ends complain about using them as a result breaking the latch.
Another beauty of the design is you can see that cable will be installed already in the latch that you can fit over the cable and push it down very easily. Installation is less than 5 minutes!
Use this Tulga door cable repair kit to permanently fix all broken door cables in both truck doors, cargo doors, liftgates, suicide doors, tailgates, rear hatches, etc.
With this kit there is no need to replace the expensive door cables!
Each kit includes a comprehensive installation guide as well!
- Ford F-150, F-250, F-350
- E-series Econoline Van E-150, E-250, E-350 •1997-2002 Expedition, Excursion, Navigator (rear door latch/liftgate)
- Ford Ranger Ext. Cab
- 1997-2008 Expedition Rear Hatch
- 1997-2004 Mazda B-series
- Lincoln Navigator
Door cable repair kits are perfect for the individual consumer as well as commercial van owners including van rentals, car dealerships, and government and private van fleets.